So I just installed a new engine in my 1992 Subaru Legacy wagon after the old one threw a rod and I've been having transmission issues.

5

Asked by Madison Sep 12, 2017 at 09:38 PM about the 1992 Subaru Legacy L Wagon AWD

Question type: Maintenance & Repair

As the title says, I've swapped out my engine for a new-to-me engine from a
junkyard. Anyways, the engine runs, quite well actually and that's not where
the problem I have is. As it turns out, I ended up not hooking up the lower
transmission cooler line to the radiator and I lost a good amount of tranny
fluid on startup. After filling up what I had believed to be the amount lost (I
had the thing up on stands and I'll get back to that in a minute) Anyways I
started it up and pulled it off the stands and although I noticed it took a little
long to get into reverse I wasn't entirely worried as I figured it was just an
anomaly. I checked the level and although it seemed okay, I think I was just
getting the extra from the fluid I had put down the tube. Anyways, I went to
drive it and the first stop sign I hit, it took a full 5 seconds after taking my foot
off of the brake for it to engage first gear and go. After checking fluid levels
again, I discovered that it seemed a bit low so I started to gradually fill it,
slowly pouring in about 2/3 of a quart in pretty small increments and driving it
short distances to let the transmission to actually start using it and it seemed
to be helping. Each time I went further before it would slip. After I noticed a
slip I would bring it back and check the level. Eventually I had it filled to the
third mark and took it out again. I was able to drive around in my
neighborhood for a while, starting and stopping with no issue. probably drove
a total of half a mile before deciding to come back home. I started to pull into
the driveway and it slipped. Anyways, after getting it on I noticed a leak
underneath that seemed to be power steering(the pump was low and it uses
the same ATF as my transmission does) So I went ahead and checked the
level, it seemed like it might have been a tad low so I put a bit more in and
pulled it down off the stands. I went to pull out of the driveway again and it
wouldn't shift at all. Not into reverse, and not into first so that I could pull it
back up on the stands. I think the leak that I was attributing solely to the
power steering might have been actually from the transmission and caused
by overfilling. I've heard that overfilling can cause leaks as well as damaging
the transmission. Being that the transmission should have enough fluid, I feel
like the fluid being low is no longer the issue. Could it be the torque
converter? I didn't pull the torque converter off of this engine considering that
both engines are the same and this one had around 40k miles less than
mine, but perhaps there was enough of a difference in them either from the
wear or maybe just slight machining imperfections. Or is it possible that I
ended up damaging the transmission? Being that the fluid level ended up
being higher than what it was supposed to be and the amount that has
leaked out seems to be quite allot.(however the level on the dipstick doesn't
seem to go down, even after letting it sit for an hour nor after I started it back
up and shifted into all the gears from park all the way down to 1st and all the
way back up again a few times.

2 Answers

Drain out the excess but the bottom line is the transmission probably needs rebuilding.

1 people found this helpful.
48,060

I suspect that the internal seals in this quarter-century old box are shot so that insufficient pressure can build for the trans to operate. Rebuilding is almost always a lost cause, so chasing a nice used one is safer and cheaper.

Your Answer:

Own this car?

Share your experience with others.

1992 Subaru Legacy

Review another car

CarGurus Experts

  • #1
    TheSubaruGuruBoston
    Reputation
    2,780
  • #2
    Anthony_60
    Reputation
    1,800
  • #3
    Tom Hawkins
    Reputation
    1,500
View All

Know more, shop wisely

Search

Related Models For Sale

Used Subaru Impreza
378 Great Deals out of 7,561 listings starting at $800
Used Toyota Camry
2,007 Great Deals out of 35,015 listings starting at $500
Used Honda Accord
1,516 Great Deals out of 29,615 listings starting at $500
Used Honda Civic
1,387 Great Deals out of 29,377 listings starting at $1,299
Used Toyota Corolla
1,591 Great Deals out of 24,050 listings starting at $1,150
Used Nissan Altima
1,290 Great Deals out of 37,640 listings starting at $900

Used Cars for Sale

2024 Subaru Legacy For Sale
26 Great Deals out of 3,254 listings starting at $23,045
2023 Subaru Legacy For Sale
17 Great Deals out of 191 listings starting at $21,993
2022 Subaru Legacy For Sale
29 Great Deals out of 346 listings starting at $15,198
2021 Subaru Legacy For Sale
39 Great Deals out of 471 listings starting at $15,995
2020 Subaru Legacy For Sale
34 Great Deals out of 389 listings starting at $12,988

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.