What is the best way to replace a rusty fuel line on a 02 Chevy silverado 1500 5.3 engine block?

Asked by Erik Jun 12, 2014 at 03:38 PM about the 2002 GMC Sierra 1500 SL 4WD Extended Cab SB

Question type: Maintenance & Repair

My fuel line has a leak in one spot and
needs to be replaced. What is the best
way to take this project without going
to the shop?

130

Joe answered 9 years ago

Whats the best way to install pre bent fuel lines

13 people found this helpful.

Mark helpful

GuruHND7C answered 4 years ago

I disconnected fuel lines from the gas tank and front of engine. I also removed evap tank. Rusty lines broke into several pieces when taking loose. I cut the flexible fuel lines under truck that are close to the front of truck with side cutters. There is a fuel line [pita] bracket attached to the upper bolt on the bellhousing. There is a 13 mm nut holding it onto the bolt. I dropped front of 4wd driveshaft. I loosened heat shield. I raised left side of body about 2". I had to loosen the abs to install middle section of 3 piece brake line.

5 people found this helpful.

Mark helpful

Your Answer:

What is the best way to replace a rusty fuel line on a 02 Chevy silverado 1500 5.3 engine block? 2 Answers

My fuel line has a leak in one spot and needs to be replaced. What is the best way to take this project without going to the shop?

2002 GMC Sierra 1500 SL 4WD Extended Cab SB

-

Maintenance & Repair
i have a 02 gmc sierra 1500 extended cab, 5speed manual tranny. the rear main transmission seal is worn out and i want to replace it myself. need acvice on removing seal 3 Answers

i need some advice on proper way to remove bad seal and installing new one. i have done this once before on the same truck and it had minor leak in it since so i dont want that to happen again. ive...

2002 GMC Sierra 1500 SL Extended Cab SB

-

Maintenance & Repair
RED AND BLACK WIRES INTO A BLACK BLOCK NEAR THE FIREWALL ON A 1997 CHEV SILVERADO 1 Answer

1997 SILVERADO WITH A 5.7 WHAT IS THIS ( SENSOR PERHAPS ) AND WHERE SHOULD IT BE MOUNTED? THE WIRES ORIGIONATE NEAR THE STEERING COLUMN / POWER BRAKE IN THE FIREWALL RED AND BLACK THEN CHANGE...

1997 GMC Sierra 1500

-

Maintenance & Repair
I have a 1989 350 5.7 TbI and I have a 96 GMC 1500 with a 305 5.0L Vortec with over 250,000 miles can I use the the heads from the Votec 305 5.0L on the 350 5.7L TBI? If so should I change the cam if so what do you recommend this is gonna be a show/driver what kind of cam and lifters do you suggest and what all do I need to do the heads (valve job, replace lifters, rockers) and what should I do to the block seeing that it only has a few miles since rebuild 3 Answers

I have a 1989 350 5.7 TbI and I have a 96 GMC 1500 with a 305 5.0L Vortec with over 250,000 miles can I use the the heads from the Votec 305 5.0L on the 350 5.7L TBI? If so should I change the cam ...

1996 GMC Sierra 1500 C1500 SL Extended Cab SB

-

Maintenance & Repair
04 gmc sierra 1500 5.3 died on me on the highway got it towed home starting going at it, hooked two different scanners to it and not throwing any codes (ecm is working bc the map was reading correctly but also the rpm was zero) anyways checked fire none checked injectors they wasnt working either(built fuel pressure then unplugged fuel relay then turned engine over and the pressure stayed the exact same) i assume it might be the crank sensor but i would think it would throw a code, anyways came back this morning and before doing anything for the hell of it i checked the gas cap and tightened it and it fired up perfect three different times and the last time i let it run and it died after bout 45 seconds (fuel pressure reads 55) and after it died its doing the same thing cranks but wont fire or start 1 Answer

died on me on the highway got it towed home starting going at it, hooked two different scanners to it and not throwing any codes (ecm is working bc the map was reading correctly but also the rpm was...

2004 GMC Sierra 1500

-

Maintenance & Repair

Looking for a Used Sierra 1500 in your area?

CarGurus has 67,550 nationwide Sierra 1500 listings starting at $3,400.

Own this car?

Share your experience with others.

2002 GMC Sierra 1500

Write a car review

Review another car

Used Chevrolet Silverado 1500

4,229 Great Deals out of 131,501 listings starting at $2,250

Used Ford F-150

6,187 Great Deals out of 135,272 listings starting at $1,500

Used GMC Sierra 2500HD

569 Great Deals out of 21,192 listings starting at $5,995

Used Toyota Tundra

1,161 Great Deals out of 34,071 listings starting at $3,399

Used Chevrolet Silverado 2500HD

1,077 Great Deals out of 31,104 listings starting at $3,800

Used Toyota Tacoma

2,055 Great Deals out of 33,945 listings starting at $2,990

Used GMC Yukon

665 Great Deals out of 11,686 listings starting at $1,499

Used Dodge RAM 1500

81 Great Deals out of 1,595 listings starting at $1,999

Used Chevrolet Tahoe

1,123 Great Deals out of 22,291 listings starting at $2,000

Used Ford F-250 Super Duty

1,400 Great Deals out of 43,531 listings starting at $2,995

Used Chevrolet Camaro

603 Great Deals out of 9,123 listings starting at $4,289

2024 GMC Sierra 1500 For Sale

98 Great Deals out of 45,289 listings starting at $28,505

2023 GMC Sierra 1500 For Sale

278 Great Deals out of 4,472 listings starting at $31,688

2022 GMC Sierra 1500 For Sale

198 Great Deals out of 1,739 listings starting at $27,600

2021 GMC Sierra 1500 For Sale

340 Great Deals out of 4,136 listings starting at $19,000

2020 GMC Sierra 1500 For Sale

213 Great Deals out of 2,398 listings starting at $17,450

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.

What is the best way to replace a rusty fuel line on a 02 Chevy silverado 1500 5.3 engine block?

2 Answers

Your Answer:

Looking for a Used Sierra 1500 in your area?

Own this car?

Share your experience with others.

Shortcuts

Search GMC Sierra 1500 Questions

CarGurus Experts

Know more, shop wisely

Related Models For Sale

Used Cars for Sale

What is the best way to replace a rusty fuel line on a 02 Chevy silverado 1500 5.3 engine block?

2 Answers

Your Answer:

Related Questions