2007 explorer with p0191, replaced the maf sensor, fuel pressure regulator sensor and fuel pump. Engine light on and after warm up, difficult to start until a half hour later

Asked by Jan 20, 2017 at 06:34 AM about the 2007 Ford Explorer Eddie Bauer

Question type: Maintenance & Repair

6 Answers

945

Maybe a faulty injector? Wiring? Check the voltage to the fuel pressure sensor first.

945

Also, I know it's a (very) long shot, but maybe try the purge valve, maybe it's stuck?

945

Also a long shot, check the PCV/breather hose. Does your dipstick pop-out? (indicating high crankcase pressure?)

87,135

P0191 FORD - Fuel Rail Pressure Sensor Circuit Range/Performance... Possible causes; Low or no fuel, Faulty Rail Pressure (FRP), Sensor FRP harness is open or shorted, FRP circuit poor electrical connection, Faulty Fuel Pump...... Engine will not start P0191 FORD Description The FRP sensor is a diaphragm strain gauge device. The FRP sensor measures the pressure difference between the fuel rail and atmospheric pressure. The FRP sensor nominal output varies between 0.5 and 4.5 volts, with 0.5 volts corresponding to 0 MPa (0 psi) gauge and 4.5 volts corresponding to 26 MPa (3771 psi) gauge. The sensor can read vacuums and may lower the output voltage to slightly below 0.5 volts. This condition is normal and is usually the case after several hours of cold soak before the vehicle dome light is turned on. The FP module is energized at the same time the dome light is commanded on. A disabled or malfunctioning dome light does not affect the FP module control. The FRP sensor is located on the fuel rail, and provides a feedback signal to indicate the fuel rail pressure to the Powertrain Control Module (PCM). The PCM uses the FRP signal to command the correct injector timing and pulse width for correct fuel delivery at all speed and load conditions. The FRP sensor, along with the fuel volume regulator (part of the fuel injection pump), form a closed loop fuel pressure control system. An electrically faulted FRP sensor results in the deactivation of the fuel injection pump. Fuel pressure to injectors is then provided only by the FP module. When the fuel injection pump is de-energized and the injectors are active, the fuel rail pressure is approximately 70 kPa (10 psi) lower than FP module pressure due to the pressure drop across the fuel injection pump. Thus, if the FP module pressure is 448 kPa (65 psi), then the fuel rail pressure would be approximately 379 kPa (55 psi) if the injectors are active.

1 people found this helpful.

So what are you suggesting I do?And please, in laymen terms. I am not a mechanic

87,135

Start by checking the fuel pressure. Not sure on this one but usually it is around 40 lbs. This would be checking the fuel pump and the fuel regulator. If the fuel pressure is not where it should be then a dead head test is performed to see if it is the fuel pump itself. All is good here then replace the Fuel Rail Pressure Sensor. You would need to make sure the wires are good at the plugin as they can break in the insulation. OR just take it in to be fixed.

1 people found this helpful.
Best Answer Mark helpful

Your Answer:

Explorer

Looking for a Used Explorer in your area?

CarGurus has 69,308 nationwide Explorer listings starting at $495.

ZIP:

Ford Explorer Experts

  • #1
    OJ
    Reputation
    12,880
  • #2
    Tom Demyan
    Reputation
    5,240
  • #3
    tennisshoes
    Reputation
    2,870
View All

Related Models For Sale

Used Ford Expedition
373 Great Deals out of 21,011 listings starting at $1,900
Used Jeep Grand Cherokee
1,164 Great Deals out of 79,945 listings starting at $1,500
Used Ford F-150
2,258 Great Deals out of 183,135 listings starting at $1,200
Used Chevrolet Tahoe
661 Great Deals out of 37,633 listings starting at $1,950
Used GMC Acadia
454 Great Deals out of 31,940 listings starting at $3,500
Used Ford Edge
996 Great Deals out of 55,774 listings starting at $3,200
Used Dodge Durango
344 Great Deals out of 25,841 listings starting at $1,000
Used Toyota Highlander
402 Great Deals out of 49,682 listings starting at $1,499
Used Toyota 4Runner
266 Great Deals out of 32,942 listings starting at $1,900
Used Honda Pilot
372 Great Deals out of 45,784 listings starting at $1,995
Used Ford Escape
1,241 Great Deals out of 94,132 listings starting at $975
Used Nissan Pathfinder
369 Great Deals out of 21,876 listings starting at $1,395
Used GMC Yukon
326 Great Deals out of 23,705 listings starting at $2,000
Used Ford Mustang
359 Great Deals out of 38,491 listings starting at $1,995

Used Cars For Sale

2018 Ford Explorer For Sale
12 Great Deals out of 40,372 listings starting at $24,346
2017 Ford Explorer For Sale
138 Great Deals out of 5,398 listings starting at $17,900
2016 Ford Explorer For Sale
138 Great Deals out of 4,754 listings starting at $13,000
2015 Ford Explorer For Sale
291 Great Deals out of 6,669 listings starting at $9,500
2014 Ford Explorer For Sale
106 Great Deals out of 2,707 listings starting at $6,888

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use.