05 Ford Escape Surging issues. Code P0511, have replace IAC, TPS, cleaned throttle body, fixed a vacuum leak off the MAP. Also replaced PCM and all plugs and coils because of an unrelated issue{apparently}....Any ideas?? Im at my wits end and so is my mechanic

20

Asked by Sep 30, 2017 at 11:50 AM about the 2005 Ford Escape

Question type: Maintenance & Repair

05 Ford Escape 3.0 V6 Surging issues. Code P0511, have replace IAC, TPS, cleaned throttle body, fixed a vacuum leak off the MAP. Also replaced PCM and all plugs and coils because of an unrelated issue{apparently}....Any ideas?? Im at my wits end and so is my mechanic

19 Answers

7,480

Have you tested and cleaned the MAF?

1 people found this helpful.
7,480

Also look at the AAC valve, test for a vacuum leak and bad valves can cause this.

1 people found this helpful.
7,480

Did your mechanic test the harness (wiring) to the IAC?

1 people found this helpful.
20

I have not cleaned the MAF, Whats an AAC Valve? My mechanic has not tested wiring harness IAC, he claims it to be a costly time consuming process. Is that correct?? I'm thinking about taking it to a different mechanic for a fresher set of eyes.....

7,480

Auxiliary air control valve = AAC. Not sure if your model has this or relies on just the IAC. I would definitely test the harness because that is part of the P0511 code. An issue with the IAC system. A new IAC will not operate without the pigtail working. It does sound like you need a new mechanic. Maybe he said this because he didn't know how to do this and is just a parts changer.

1 people found this helpful.
20

Def taking it elsewhere for a fresher look. Its gotta be the wiring harness. How hard and expensive of a job is this? Any idea??

7,480

Not very for a automotive technician with the right electronic tools. If it is determined to be bad, then they will have to see if it is a control wire or a power feed and either solder the break or solder a new length and connector. 1 hour plus diagnosis in most cases.

1 people found this helpful.
20

Took it today to a different mechanic and they cant find anything. Wire harness has been tested and the car is not acting up for them. He's thinking it could be the PCM but that has just been replaced with a new one so now this mechanic has no idea either. This car only acts up intermittently and never when its in the shop. The only code is P0511.....so any thoughts??

7,480

Has anyone done a smoke test on the vacuum system? Do you have an electronic throttle body?

1 people found this helpful.
20

Vacuum leak was detected and fixed. Electronic Throttle Body? Maybe? I have replaced the TPS. Throttle body is clean and looks good. I guess I can start throwing more parts at it? Only thing not changed out would be the MAF Sensor, MAP Sensor and ETB. Seriously frustrated at this point. Could it be the new PCM? This was an issue before I had it replace so I'm kinda thinking no but who knows at this point...

1 people found this helpful.
7,480

I would seriously not throw parts at this but test these items and identify a faulty part. There are many YouTube videos out there to test all these listed parts. All of these are too expensive to just start buying and replacing. Every one of these last few parts you have not replaced could be your issue. They all have that ability to mess with your air/fuel/computer functions.

2 people found this helpful.
7,480

Not sure who you are taking this to but a true technician could find your issue. A bidirectional scanner with a scope and live data could determine what values are out of wack and direct them to the system or component not meeting its demand.

7,480

Your mechanic should be looking at rpms, recommended rpms, IAC %, throttle position sensor voltage and the voltage square wave on a scope to determine if it is indeed this IAC. I know you said you put a new one in but this 511 code points to this IAC. Is your gaskets new also?

1 people found this helpful.
7,480

Does it run better if you unplug either the MAF or the map sensor?

1 people found this helpful.
7,480

Has your mechanic tested fuel pressure? A clogged fuel filter will cause this surging. I have encountered this on a few cars in the last 10 years. Your pcm will overcompensate for lack of fuel and open the injectors.

2 people found this helpful.
20

I think so? I'll check. Fuel Filter was changed about 30,000 miles ago.

20

Replaced IAC 3 times. New Gasket. Have not unplugged MAF OR MAP. Not really sure how much tests & diagnostic have been done. I know they've run it hooked up to a computer looking for anything. At this point wondering if I should take it to Ford, maybe they'd better know what to look at.

20

Problem fixed. Mechanic could'nt detect problem so he decided to run a temporary jumper between PCM & IAC. Problem solved! Short was in Pigtail to IAC. Has been rewired now & is running good. Kinda frustrating that no one could detect this. The 2 different mechanics both said that unless it was actually acting up while its hooked up to a monitor then it wasn't detectable.

7,480

We knew it had to be the harness since it was a code for this component and you replaced the IAC 3 Times. Again, a true technician would have done a step by step follow the issue test and found this no communication issue with the wiring. Good to hear

Your Answer:

Escape

Looking for a Used Escape in your area?

CarGurus has 105,699 nationwide Escape listings starting at $995.

ZIP:

Ford Escape Experts

  • #1
    Bratts
    Reputation
    3,410
  • #2
    kbro
    Reputation
    1,990
  • #3
    Janey07
    Reputation
    1,530
View All

Related Models For Sale

Used Ford Explorer
1,541 Great Deals out of 83,995 listings starting at $1,275
Used Honda CR-V
1,015 Great Deals out of 70,595 listings starting at $990
Used Toyota RAV4
1,031 Great Deals out of 43,043 listings starting at $2,000
Used Chevrolet Equinox
1,854 Great Deals out of 83,225 listings starting at $999
Used Ford Fusion
1,287 Great Deals out of 49,473 listings starting at $1,499
Used Ford F-150
4,039 Great Deals out of 219,143 listings starting at $1,195
Used Ford Focus
996 Great Deals out of 38,749 listings starting at $1,499
Used Jeep Grand Cherokee
1,413 Great Deals out of 87,833 listings starting at $900
Used Hyundai Tucson
346 Great Deals out of 20,828 listings starting at $2,400
Used Hyundai Santa Fe
281 Great Deals out of 30,863 listings starting at $1,599
Used Kia Sportage
310 Great Deals out of 21,521 listings starting at $495

Used Cars for Sale

2019 Ford Escape For Sale
55,118 listings starting at $16,700
2018 Ford Escape For Sale
138 Great Deals out of 16,645 listings starting at $12,999
2017 Ford Escape For Sale
331 Great Deals out of 6,892 listings starting at $10,500
2016 Ford Escape For Sale
455 Great Deals out of 8,725 listings starting at $7,650
2015 Ford Escape For Sale
190 Great Deals out of 4,073 listings starting at $7,000

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.