2004 AVEO STARTS BUT FAILS AFTER A FEW SECONDS I HAVE CHANGED MOST OF THE SENSORS AND CLEANED THROTTLE BODY CLEARED FAULT CODES BUT STILL HAVING SAME PROBLEM WHAT CAN I DO TO REPAIR COST IS AN ISSUE

Hugo Van Tonder
10

Asked by Hugo Mar 27, 2014 at 09:35 PM about the 2004 Chevrolet Aveo Base

Question type: Maintenance & Repair

I AM AT WITS END CHANGED MOST OF THE SENSORS AND HAD THE REST
TESTED BY A REPUTABLE ECU GURU BUT NO LUCK CAR STARTS AND RUNS A
FEW SECONDS THEN DIES FUEL PRESSURE 55 PSI ALL CONNECTIONS CHECKED
BATTERY FULLY CHARGED NO FAULT CODES CONVERTER CHANGED MANUAL
TRANSMISSION

6 Answers

Billdarr47
35

Strange but fuel pressure seems good ... what about fuel flow? When is the kast time you changed the fuel filter? It might be clogged. also turn on the iginition, not start mide and listen for the fuel pump, there should be a bit of noise or clicking indicating it's pumping. Do much to suggest. Billdarr47

2 out of 2 people think this is helpful.
Hugo Van Tonder
10

FILERS CHANGED DONE ALL THE CHECKS SO FAR BUT TO NO AVAIL FUEL SUPPLY CONSTANT WHEN STARTING PUMP RUNS UNTIL IT DIES AFTER THAT A SECOND OR SO LONGER THEN PUMP STOPS

1 out of 1 people think this is helpful.
BoholMark
19,445

By chance, have you checked the fuel pump relay?

Billdarr47
35

I don't know newer cars systems but there could be a turn over solinoid, cutting off the fuel flow and it maybe activated do to a faulty signal, might be ground or plus 12v activated ... check on it, I think this is my last idea, for you. Regards, Billdarr47.

1 out of 1 people think this is helpful.
You think this is helpful.
Hugo Van Tonder
10

Thank you all for your help and advise i have finally found the problem the pump would pressurize like normal but as soon as it runs a few seconds the pressure just drops to a bare 5.5 psi as soon as it dies and you restart the pressure is again 55 psi replaced the pump car running like a dream thanx again

BoholMark
19,445

Glad to hear that you have solved the problem. Something like that can drive you crazy!

Your Answer

Add photo

Related Questions

  • Engine Shutting off after about 10-20 seconds on 2004 Silverado 1500 20 answers

    Can anyone shed some light on this problem. After driving my 04' Silverado 1500 all day without any problems, after the truck sat in the driveway for a couple of hours, the truck started right up, but...

    2004 Chevrolet Silverado 1500

    -

    Maintenance & Repair

  • multiple random misfires 3 answers

    Ok...Hopefully someone will be able to help. I have been getting p0300 codes coming up on '01 Chevy Express 3500 (5.7 litre) over the last week. It only throws the codes while I'm idling. I have check...

    2001 Chevrolet Express G3500 Passenger Van Extended

    -

    Maintenance & Repair

  • Ok, Replaced Spider Fuel Injector but now idle issue, details inside 31 answers

    Alright so my random misfire issue P0300, P0306 was handled by putting in a new spider fuel injector. I discovered that the regular was missing and opted to replace the whole thing. Put in new gasket ...

    1997 Chevrolet S-10 2 Dr LS Extended Cab SB

    -

    Maintenance & Repair

  • My Chevy Lumina will not start hot, runs/idles rough 100 answers

    I have a 1996 Chevy Lumina LS, 3.1 V6. Over the last 18 months I have had problems with it getting hot (not engine coolant) and not starting after driving for a while or running a few errands of 10-20...

    1996 Chevrolet Lumina 4 Dr LS Sedan

    -

    Maintenance & Repair

  • rough idle until I spray Mass Air Flow Cleaner in the throttle control body 14 answers

    My sunfire has 101,000 miles, idles rough like it has a bad MASS AIR FLOW SENSOR. Seems to run fine as soon as you get going. The check engine light (IS NOT ON. )When you spray Mass Air flow sensor cl...

    1998 Pontiac Sunfire 2 Dr SE Coupe

    -

    Maintenance & Repair

Aveo
Looking for a Used Aveo in your area?
CarGurus has 2,755 nationwide Aveo listings starting at $1,495.
ZIP:

Search Chevrolet Aveo Questions

Chevrolet Aveo Experts

#1 Tom Demyan
Tom Demyan
Reputation 140
#2 Randy Wood
Randy Wood
Reputation 100
#3 Mike Bonnell
Mike Bonnell
Reputation 90
View All

Related Models For Sale

Used Chevrolet Cobalt"
316 Great Deals out of 6,949 listings starting at $900
Used Honda Civic"
1,020 Great Deals out of 63,514 listings starting at $1,199
Used Ford Focus"
1,384 Great Deals out of 63,785 listings starting at $1,295
Used Hyundai Accent"
315 Great Deals out of 12,940 listings starting at $1,000
Used Toyota Corolla"
1,092 Great Deals out of 61,582 listings starting at $1,000
Used Nissan Sentra"
695 Great Deals out of 40,853 listings starting at $1,500
Used Chevrolet Spark"
69 Great Deals out of 11,449 listings starting at $6,995
Used Toyota Yaris"
168 Great Deals out of 5,905 listings starting at $2,700
Used Kia Rio"
137 Great Deals out of 7,368 listings starting at $1,980
Used Ford Fiesta"
310 Great Deals out of 21,700 listings starting at $4,995
Used Hyundai Elantra"
749 Great Deals out of 52,147 listings starting at $1,500
Used Chevrolet Malibu"
1,301 Great Deals out of 81,277 listings starting at $1,595

Used Cars For Sale

2011 Chevrolet Aveo For Sale
47 Great Deals out of 652 listings starting at $5,995
2010 Chevrolet Aveo For Sale
28 Great Deals out of 425 listings starting at $5,490
2009 Chevrolet Aveo For Sale
32 Great Deals out of 507 listings starting at $3,495
2008 Chevrolet Aveo For Sale
13 Great Deals out of 352 listings starting at $2,995
2007 Chevrolet Aveo For Sale
14 Great Deals out of 295 listings starting at $2,900